Skip to main content

MINI REVIEW article

Front. Microbiol., 02 May 2016
Sec. Food Microbiology

Potential Impact of the Resistance to Quaternary Ammonium Disinfectants on the Persistence of Listeria monocytogenes in Food Processing Environments

  • 1Departamento de Tecnología de Alimentos, Instituto Nacional de Investigación y Tecnología Agraria y Alimentaria, Madrid, Spain
  • 2Unidad de Biología Computacional, Unidad Funcional de Investigación de Enfermedades Crónicas, Instituto de Salud Carlos III, Madrid, Spain

The persistence of certain strains of Listeria monocytogenes, even after the food processing environment has been cleaned and disinfected, suggests that this may be related to phenomena that reduce the concentration of the disinfectants to subinhibitory levels. This includes (i) the existence of environmental niches or reservoirs that are difficult for disinfectants to reach, (ii) microorganisms that form biofilms and create microenvironments in which adequate concentrations of disinfectants cannot be attained, and (iii) the acquisition of resistance mechanisms in L. monocytogenes, including those that lead to a reduction in the intracellular concentration of the disinfectants. The only available data with regard to the resistance of L. monocytogenes to disinfectants applied in food production environments refer to genotypic resistance to quaternary ammonium compounds (QACs). Although there are several well-characterized efflux pumps that confer resistance to QACs, it is a low-level resistance that does not generate resistance to QACs at the concentrations applied in the food industry. However, dilution in the environment and biodegradation result in QAC concentration gradients. As a result, the microorganisms are frequently exposed to subinhibitory concentrations of QACs. Therefore, the low-level resistance to QACs in L. monocytogenes may contribute to its environmental adaptation and persistence. In fact, in certain cases, the relationship between low-level resistance and the environmental persistence of L. monocytogenes in different food production chains has been previously established. The resistant strains would have survival advantages in these environments over sensitive strains, such as the ability to form biofilms in the presence of increased biocide concentrations.

Introduction

Listeria monocytogenes is a Gram-positive foodborne pathogen that can cause listeriosis, a relatively uncommon illness with a 20–30% case fatality rate (Silk et al., 2012; CDC, 2014; de Noordhout et al., 2014; EFSA and ECDC, 2014). The majority of cases of human listeriosis are caused by contaminated processed foods (McLauchlin et al., 2004; Lianou and Sofos, 2007). Although the original source of the contamination may be the raw food materials used in the processing plants, the strains of L. monocytogenes present in the final food products are usually different from the strains in the raw materials (Tompkin, 2002; Thévenot et al., 2006). In addition, when listeriosis outbreaks have been investigated, contamination is usually traced to the processing environment and equipment (Orsi et al., 2008; Nakari et al., 2014). This suggests that the contamination mainly occurs during the processing of food and is primarily due to strains from the processing plant environment (Malley et al., 2015; Garner and Kathariou, 2016).

Environmental Persistence

The molecular characterization of L. monocytogenes isolates from the food processing environment regularly shows the presence of a reduced number of molecular subtypes and the long-term persistence of specific strains that can contaminate food and cause foodborne listeriosis (Ortiz et al., 2010; Ferreira et al., 2011; Morganti et al., 2015). The detection of highly similar isolates from different areas inside single establishments, and their environmental persistence, is a matter of concern for the hygienic management of food establishments (Cramer, 2006; Ferreira et al., 2014).

Carpentier and Cerf (2011) assert that L. monocytogenes persistence is primarily a random process given that “there are no strains with unique properties that lead to persistence but harborage sites in food industry premises and equipment where L. monocytogenes can persist.” Persistent strains of L. monocytogenes have occasionally been isolated in food processing environments after cleaning and disinfection (Lundén et al., 2003b; Soumet et al., 2005; Thévenot et al., 2006; Bērziņš et al., 2010; Ortiz et al., 2016). As demonstrated by the findings of studies reviewed here, the persistence of certain strains of L. monocytogenes after cleaning and disinfecting is not a completely random process, but rather an event related to different situations that result in subinhibitory concentrations of disinfectants at different scales. This includes: (i) local environmental conditions that can lead to the formation of niches or reservoirs that are difficult for disinfectants to reach; (ii) microorganisms that form biofilms and create microenvironments in which adequate concentrations of disinfectants cannot be attained; and (iii) the acquisition of resistance mechanisms in L. monocytogenes, including those that lead to a reduction in the intracellular concentration of the disinfectants.

There are numerous factors in food processing plants, such as insufficient cleaning before disinfection, disinfection of wet surfaces, and dosage failure that can lead to subinhibitory concentrations of disinfectants, thus reducing their efficiency. This reduction may be especially significant in certain niches or reservoirs in which water and organic matter are abundant, creating an environment where bacteria can survive and multiply readily (Cramer, 2006; Carpentier and Cerf, 2011).

Failure to effectively clean and disinfect the processing plant environment may contribute to biofilm formation in certain niches, leading to bacterial persistence (Gandhi and Chikindas, 2007; Renier et al., 2011). Cells embedded in the biofilm matrix display an increased resistance to biocide treatments (Bridier et al., 2011). However, the resistance to disinfectants in sessile cells (biofilms) and in planktonic cells (free-floating) are clearly different phenomena (Fatemi and Frank, 1999; Norwood and Gilmour, 2000; Stopforth et al., 2002; Kastbjerg and Gram, 2009). Resistance of biofilms to disinfectants is considered to be a form of “phenotypic resistance” since bacterial resistance is mainly induced by a physiological adaptation to the biofilm mode of life and can be lost or markedly reduced when biofilm cells revert to the planktonic state (Pan et al., 2006; Bridier et al., 2011). In contrast, in the case of planktonic cells, a bacterial strain is defined as being resistant to a biocide if it is not inhibited by a specific concentration that usually inhibit the majority of other strains (Bridier et al., 2011); that is, planktonic cell resistance depends on intrinsic cellular attributes such as intra-species (i.e., strain) variability in the MIC of a given disinfectant (Kastbjerg and Gram, 2012).

Resistance to Disinfectants

The only available data with regard to the resistance of L. monocytogenes to disinfectants applied in food production environments refer to genotypic resistance to QACs (Hegstad et al., 2010; Gerba, 2015). BAC is typically used in studies assessing in vitro the activity of QACs. Increased MICs of BAC have been found in L. monocytogenes strains from different food production chains in different countries (Table 1). BAC resistance in L. monocytogenes is a low-level resistance. This means that the resistant strains only have a two to eight-fold increase in the MIC compared to the rest of the strains (Table 1). This resistance does not lead to QAC resistance at the concentrations that are normally used in the food industry (typically 200–1000 mg L-1) (SCENIHR, 2009; Ferreira et al., 2014; Tezel and Pavlostathis, 2015). Therefore, QACs are considered to be an effective means of eliminating the resistant L. monocytogenes strains (Kastbjerg and Gram, 2009, 2012).

TABLE 1
www.frontiersin.org

TABLE 1. Reports of resistance to BAC in planktonic cells of Listeria monocytogenes.

Some of these studies have been conducted with a large number of strains, and they report a variable frequency of resistant strains due to the diversity of the selection criteria for the strains studied. For example, the study of Ortiz et al. (2016) reports a very high frequency of resistant isolates because only samples of disinfected surfaces are included (Table 1). In some cases, selection for L. monocytogenes isolates resistant to QACs has been associated with the repeated use of this class of disinfectants (Heir et al., 2004; Ortiz et al., 2014a, 2016).

In food processing environments, L. monocytogenes is exposed to different disinfectants and sanitizers, and sometimes at subinhibitory cocentrations. This is particularly true for disinfectants that are not fully biodegradable which may persist in sewage for long periods. For example, QACs are biodegradable only under aerobic conditions, resulting in continuously fluctuating concentration gradients (Tezel and Pavlostathis, 2015). As a result, the microorganisms are frequently exposed to subinhibitory concentrations of QACs. Repeated exposure to subinhibitory concentrations of QACs and prolonged environmental persistence of certain strains may facilitate the development of resistance over time (Ortiz et al., 2014a). Subinhibitory concentrations of antimicrobials may cause genetic changes in the bacteria by means of different pathways, including an increase in free radicals inside the cell or oxidative stress (Liu et al., 2016). This can trigger the SOS response which can promote either the expression of genes involved in horizontal gene transfer or mutagenesis through induction of the error-prone DNA polymerases (Shapiro, 2015).

Strains of L. monocytogenes with genotypic resistance to QACs may have mutations that lead to a reduction in cell permeability (Mereghetti et al., 2000; To et al., 2002). For instance, resistant strains may have modifications in membrane fatty acids and phospholipids (Fox et al., 2011), which can lead to a more anionic and hydrophobic cell surface. This makes it difficult for QACs to pass through the membrane and enter the cell (To et al., 2002).

In other cases, resistance to QACs in L. monocytogenes may be due to the acquisition of QAC-specific efflux pumps through recombinant elements and mobile genetic elements. Different genetic markers have been identified that confer L. monocytogenes with a low-level resistance to QACs, including the resistance determinant bcrABC (Elhanafi et al., 2010) and the qacH gene of transposon Tn6188 (Müller et al., 2013), as well as various qac determinants originally identified in staphylococci (Xu et al., 2014). All of these genes encode components of the efflux system in the small multidrug resistance (SMR) protein family group (Blair et al., 2015). Plasmids are also associated with L. monocytogenes resistance to BAC (Elhanafi et al., 2010). Furthermore, plasmids with genes that confer resistance to BAC can be transferred between different pathogenic and non-pathogenic species of Listeria in the presence of QACs. This process also leads to the co-selection of resistance against heavy metals (Katharios-Lanwermeyer et al., 2012). In several screening studies of resistant strains, the qacH gene and the determinant bcrABC have been found (Müller et al., 2013). In one study, for example, resistance to BAC has been associated with the qacH gene in the majority (80%) of the tested strains, and a minority of the strains (12%) have been associated with the determinant bcrABC (Ebner et al., 2015). Nevertheless, in other studies, only the qacH gene has been detected (Ortiz et al., 2014b, 2016), while in others a clear predominance of the determinant bcrABC has been reported (Dutta et al., 2013).

On the other hand, in some studies, the aforementioned determinants are not detected in certain resistant strains (Ortiz et al., 2014b, 2016; Ebner et al., 2015). In these cases, resistance may be due to the overexpression of endogenous efflux pumps due to mutations in regulatory elements. This can occur due to exposure to QACs or the stress induced by these compounds (Tezel and Pavlostathis, 2015). These pumps are usually chromosomally encoded and affect a broad spectrum of antimicrobial compounds (Buffet-Bataillon et al., 2012; Ortiz et al., 2016). In certain strains of L. monocytogenes that are resistant to BAC, QAC resistance has been associated with the overexpression of efflux pumps in the MFS (major facilitator superfamily) group (Blair et al., 2015), such as MdrL (multidrug resistant Listeria) and Lde (Listeria drug efflux) (Romanova et al., 2006; Rakic-Martinez et al., 2011). Recently, the overexpression of a new L. monocytogenes efflux pump (encoded by emrE) has been implicated in the resistance to QACs (Kovacevic et al., 2015).

The Problem of Defining and Detecting Resistance

For various reasons, data on bacterial resistance to biocides is often difficult to interpret and compare (Buffet-Bataillon et al., 2012). A potential reason for the difficulty in interpreting data on bacterial resistance to biocides is the absence of clear criteria for defining a microorganism as resistant to disinfectants. An ecological concept of resistance to biocides has been proposed based on the “natural” susceptibility of a given species (Morrissey et al., 2014). According to this criterion, an isolate is defined as resistant when it is not inhibited by a concentration that would inhibit most of the strains of that particular species. The resistant isolate is typically phenotypically different from the wild type because it has acquired a resistance mechanism through mutation or horizontal gene transfer (EFSA, 2008; SCENIHR, 2009; Buffet-Bataillon et al., 2012; Morrissey et al., 2014). This commonly happens to L. monocytogenes strains that are resistant to BAC (Mereghetti et al., 2000; Elhanafi et al., 2010; Müller et al., 2013).

Another reason for the difficulty in comparing results on bacterial resistance is the lack of standardized tests for examining in vitro susceptibility to disinfectants (Buffet-Bataillon et al., 2012). Susceptibility to disinfectants is often determined through the MIC technique (usually employing agar dilution or broth dilution methods) (Table 1). However, in some cases, the MICs obtained through different methods can produce different results, which is why standardization is necessary. The influence of the culture media is especially important to consider when detecting low-level resistance (Table 1). Therefore, we recommend the use of standardized clinical protocols that are designed to evaluate the inhibitory activity of antibiotics (EUCAST, 2000; CLSI, 2009). Consequently, changes in the MIC of the disinfectant of several “test” strains can be measured and the resistant strains can be detected (Ortiz et al., 2014a). In contrast, current standardized tests for the evaluation and comparison of commercial disinfectants measure the bactericidal activity of the products by using one specific “reference” strain (European Committee for Standardisation, 2010; Buffet-Bataillon et al., 2012); the different tests use planktonic cells (suspension test) or cells attached to stainless steel (carrier test).

Despite the low MIC values, L. monocytogenes strains with low-level resistance to QACs have efflux pumps that can reduce the intracellular concentration of the biocides to subinhibitory levels, “such that the bacterium can survive longer than may have been predicted from the MIC for that organism” (Piddock, 2006). For quinolone-resistant Staphylococcus aureus, for example, the MICs afforded by mutations in the gene encoding the target topoisomerase are too low to allow survival, and it has been proposed that efflux gives rise to low intracellular concentrations of the drugs (Piddock, 2006). In addition, microorganisms in the environment may be exposed to enormously variable concentrations of QACs. For example, in domestic wastewater the average concentration of QACs is approximately 0.5 mg L-1, and in wastewater treatment plant effluents the concentration decreases to 0.05 mg L-1 (Tezel and Pavlostathis, 2015). As a result, low-level resistance to QACs may contribute to the persistence of L. monocytogenes in the environment.

Is Persistence Linked to Resistance?

The hypothesis that the persistence of certain subtypes of L. monocytogenes is linked to resistance to disinfectants has been investigated in numerous studies (revised by Ferreira et al., 2014). However, an association between low-level resistance to QACs and persistence of the pathogen in different food processing environments has been demonstrated only in a few cases (Aase et al., 2000; Lundén et al., 2003a; Fox et al., 2011; Ortiz et al., 2014a, 2016).

The susceptibility of 200 strains of L. monocytogenes to BAC has been investigated in a fish production plant in Norway. In this study, 10% of the strains are resistant strains, and all of these are previously identified persistent strains (Aase et al., 2000; Table 1). The relationship between persistence and resistance to two QACs has also been analyzed in four strains of poultry originating in Finland. In one of the persistent strains, the MIC values are higher (2.5–5.0 mg L-1) than the MICs for the rest of the strains (0.63–1.25 mg L-1) (Lundén et al., 2003a). Additionally, the MICs of a different QAC, benzethonium chloride, have been analyzed in 11 strains of L. monocytogenes from the cheese industry in Ireland. Two of the persistent strains have MIC values of 1.5–4.0 mg L-1, compared with a MIC of 0.5 mg L-1 for the rest of the strains (Fox et al., 2011). In an Iberian pork processing plant in Spain, 29 different subtypes of L. monocytogenes have been identified over 3 years, and the resistance to BAC has been associated with the persistence of three subtypes of the molecular serotype 1/2a (Ortiz et al., 2014a). Subsequently, in a similar plant, five different molecular subtypes have been detected in environmental samples from clean, disinfected surfaces (Ortiz et al., 2016). In these eight persistent subtypes, a low-level resistance to QACs has been confirmed. In both of these studies, the MIC values of BAC are 10–20 mg L-1 in the resistant strains and 1.25–2.5 mg L-1 in the sensitive strains (Table 1). To improve the control of L. monocytogenes in food processing environments, additional research is needed to evaluate attributes specific to resistant and persistent strains of this pathogen.

Advantages of Resistant Strains for Persisting in the Environment

The L. monocytogenes strains that have acquired mechanisms of resistance to QACs may have specific advantages over sensitive strains with regard to persisting in food processing environments. For example, the influence of residual QACs may vary in sensitive strains and resistant strains, as an optimum concentration (inhibitory) for the former may be suboptimum (subinhibitory) for the latter. This has been confirmed by Ortiz et al. (2014b) in strains of L. monocytogenes resistant to BAC. When biofilm formation in the presence of BAC has been studied, only three concentrations of BAC (1.25, 2.5, and 5 mg L-1) have been identified that show different effects on the biofilm formation by the group of strains of L. monocytogenes included in the study. It was observed that certain resistant strains are able to form biofilm at 5 mg L-1, a concentration of BAC that is inhibitory for most strains (Ortiz et al., 2014b). However, biofilm formation in the presence of increased concentrations of BAC may differ between resistant strains with similar MICs but different genetic determinants of BAC resistance. For example, biofilm production in the presence of BAC differs between persistent L. monocytogenes strains belonging to sequence type ST121 that have transposon Tn6188 with the gene qacH, and prfA mutants belonging to sequence type ST31 that are also persistent and resistant (Ortiz et al., 2016). Figure 1 shows the percentage of the biofilm formed in the presence of BAC relative to the biofilm formed without BAC by two representative ST31 and ST121 resistant strains. Thus, ST121 strains are able to form biofilm in the presence of BAC concentrations (5 mg L-1) higher than the MIC of sensitive strains (1.25–2.5 mg L-1) (Ortiz et al., 2016; Figure 1). These results may help explain the persistence of the resistant ST121 strains (Ortiz et al., 2014b, 2016; Schmitz-Esser et al., 2015).

FIGURE 1
www.frontiersin.org

FIGURE 1. Effect of BAC on biofilm formation by representative sequence type (ST) 31 and ST121 Listeria monocytogenes strains. The results are presented as the average percentages of three measurements of biofilm formed with the addition of BAC concentrations of 1.25 mg L-1, 2.5 mg L-1 and 5 mg L-1, compared with the control without the addition of BAC (0 mg L-1, 100%). Reduced () or increased (∗∗) percentages of biofilm differed significantly from the controls without BAC (p < 0.05, student’s t-test), adapted from Ortiz (2015).

Additionally, studies have shown that L. monocytogenes strains that are resistant to QACs can form biofilms faster than sensitive strains, which increases the likelihood of their survival (Nakamura et al., 2013). The expression of certain genes associated with the stress response or its regulation may also lead to an increased formation of biofilms by resistant strains (van der Veen and Abee, 2010). Therefore, the exposure of L. monocytogenes to subinhibitory concentrations of QACs and the consequent selection of resistant microorganisms may increase the ability of these bacteria to form biofilms and survive future treatment with high concentrations of the same compounds (Tezel and Pavlostathis, 2015).

Concluding Remarks

In recent years, the evaluation of the relationship between resistance to disinfectants and persistence, have allowed researchers to identify L. monocytogenes persistent subtypes that are resistant to disinfectants. The low-level resistance to QACs that has been detected in these subtypes is not a phenotypic adaptation, but rather, it is a stable genotypic resistance that is relatively frequent in certain environments and has important implications. For example, the formation of biofilms by resistant strains in the presence of biocide concentrations that are inhibitory for the sensitive strains may undoubtedly have an effect on their environmental survival. Therefore, a better understanding of the ecological and genetic characteristics of the strains resistant to QACs is needed, as well as standardization and consensus of the techniques used to detect the resistant strains.

Author Contributions

All authors listed, have made substantial, direct and intellectual contribution to the work, and approved it for publication.

Conflict of Interest Statement

The authors declare that the research was conducted in the absence of any commercial or financial relationships that could be construed as a potential conflict of interest.

Acknowledgments

The authors were supported by grants RTA2011-00098-C02 and RTA2014-00045-C03 (Ministry of Economy and Competitiveness, Spain, Plan Nacional I+D+i co-financed by INIA and FEDER) during the preparation of this manuscript.

Abbreviations

BAC, benzalkonium chloride; MIC, minimum inhibitory concentration; QACs, quaternary ammonium compounds.

References

Aarestrup, F. M., Knöchel, S., and Hasman, H. (2007). Antimicrobial susceptibility of Listeria monocytogenes from food products. Foodborne Pathog. Dis. 4, 216–221. doi: 10.1089/fpd.2006.0078

PubMed Abstract | CrossRef Full Text | Google Scholar

Aase, B., Sundheim, G., Langsrud, S., and Rørvik, L. M. (2000). Occurrence of and a possible mechanism for resistance to a quaternary ammonium compound in Listeria monocytogenes. Int. J. Food Microbiol. 62, 57–63. doi: 10.1016/S0168-1605(00)00357-3

PubMed Abstract | CrossRef Full Text | Google Scholar

Bērziņš, A., Hellström, S., Siliņš, I., and Korkeala, H. (2010). Contamination patterns of Listeria monocytogenes in cold-smoked pork processing. J. Food Prot. 73, 2103–2109.

PubMed Abstract | Google Scholar

Blair, J. M., Webber, M. A., Baylay, A. J., Ogbolu, D. O., and Piddock, L. J. (2015). Molecular mechanisms of antibiotic resistance. Nat. Rev. Microbiol. 13, 42–51. doi: 10.1038/nrmicro3380

PubMed Abstract | CrossRef Full Text | Google Scholar

Bridier, A., Briandet, R., Thomas, V., and Dubois-Brissonnet, F. (2011). Resistance of bacterial biofilms to disinfectants: a review. Biofouling 27, 1017–1032. doi: 10.1080/08927014.2011.626899

PubMed Abstract | CrossRef Full Text | Google Scholar

Buffet-Bataillon, S., Tattevin, P., Bonnaure-Mallet, M., and Jolivet-Gougeon, A. (2012). Emergence of resistance to antibacterial agents: the role of quaternary ammonium compounds-a critical review. Int. J. Antimicrob. Agents 39, 381–389. doi: 10.1016/j.ijantimicag.2012.01.011

PubMed Abstract | CrossRef Full Text | Google Scholar

Carpentier, B., and Cerf, O. (2011). Review–persistence of Listeria monocytogenes in food industry equipment and premises. Int. J. Food Microbiol. 145, 1–8. doi: 10.1016/j.ijfoodmicro.2011.01.005

PubMed Abstract | CrossRef Full Text | Google Scholar

CDC (2014). Incidence and trends of infection with pathogens transmitted commonly through food — foodborne diseases active surveillance network, 10 U.S. sites, 2006–2013. Morb. Mortal. Wkly. Rep. 63, 328–332.

Google Scholar

CLSI (2009). Clinical Laboratory Standards Institute. Methods for Dilution Antimicrobial Susceptibility Tests for Bacteria that Grow Aerobically. Approved Standard, 8th ed. M7-A8. Wayne, PA: CLSI.

Cramer, M. M. (2006). Food Plant Sanitation. Design, Maintenance, and Good Manufacturing Practices. Boca Raton, FL: CRC Press.

Google Scholar

de Noordhout, C. M., Devleesschauwer, B., Angulo, F. J., Verbeke, G., Haagsma, J., Kirk, M., et al. (2014). The global burden of listeriosis: a systematic review and meta-analysis. Lancet Infect. Dis. 14, 1073–1082. doi: 10.1016/S1473-3099(14)70870-9

PubMed Abstract | CrossRef Full Text | Google Scholar

Dutta, V., Elhanafi, D., and Kathariou, S. (2013). Conservation and distribution of the benzalkonium chloride resistance cassette bcrABC in Listeria monocytogenes. Appl. Environ. Microbiol. 79, 6067–6074. doi: 10.1128/AEM.01751-13

PubMed Abstract | CrossRef Full Text | Google Scholar

Ebner, R., Stephan, R., Althaus, D., Brisse, S., Maury, M., and Tasara, T. (2015). Phenotypic and genotypic characteristics of Listeria monocytogenes strains isolated during 2011-2014 from different food matrices in Switzerland. Food Control 57, 321–326. doi: 10.1016/j.foodcont.2015.04.030

CrossRef Full Text | Google Scholar

EFSA (2008). Scientific opinion of the panel on biological hazards on a request from the European Food Safety Authority on foodborne antimicrobial resistance as a biological hazard. EFSA J. 765, 1–87.

Google Scholar

EFSA and ECDC (2014). The European Union summary report on trends and sources of zoonoses, zoonotic agents and food-borne outbreaks in 2012. EFSA J. 12, 3547.

PubMed Abstract | Google Scholar

Elhanafi, D., Dutta, V., and Kathariou, S. (2010). Genetic characterisation of plasmid associated benzalkonium chloride resistance determinants in a strain of Listeria monocytogenes from the 1998–1999 outbreak. Appl. Environ. Microbiol. 76, 8231–8238. doi: 10.1128/AEM.02056-10

PubMed Abstract | CrossRef Full Text

EUCAST (2000). European committee on antimicrobial susceptibility testing. Determination of minimum inhibitory concentrations (MICs) of antibacterial agents by agar dilution. Definitive document E.DEF 3.1. Clin. Microbiol. Infect. 6, 509–515.

PubMed Abstract | Google Scholar

European Committee for Standardisation (2010). European Standard EN 1276:2009/AC:2010. Chemical Disinfectants and Antiseptics–Quantitative Suspension Test for the Evaluation of Bactericidal Activity of Chemical Disinfectants and Antiseptics used in Food, Industrial, Domestic and Institutional Areas - Test Method and Requirements (phase 2, step 1). Brussels: European Committee for Standardisation.

Fatemi, P., and Frank, J. F. (1999). Inactivation of Listeria monocytogenes/Pseudomonas biofilms by peracid sanitizers. J. Food Prot. 62, 761–765.

PubMed Abstract | Google Scholar

Ferreira, V., Barbosa, J., Stasiewicz, M., Vongkamjan, K., Moreno Switt, A., Hogg, T., et al. (2011). Diverse geno- and phenotypes of persistent Listeria monocytogenes isolates from fermented meat sausage production facilities in Portugal. Appl. Environ. Microbiol. 77, 2701–2715. doi: 10.1128/AEM.02553-10

PubMed Abstract | CrossRef Full Text | Google Scholar

Ferreira, V., Wiedmann, M., Teixeira, P., and Stasiewicz, M. J. (2014). Listeria monocytogenes persistence in food-associated environments: epidemiology, strain characteristics, and implications for public health. J. Food Prot. 77, 150–170. doi: 10.4315/0362-028X.JFP-13-150

PubMed Abstract | CrossRef Full Text | Google Scholar

Fox, E. M., Leonard, N., and Jordan, K. (2011). Physiological and transcriptional characterization of persistent and nonpersistent Listeria monocytogenes isolates. Appl. Environ. Microbiol. 77, 6559–6569. doi: 10.1128/AEM.05529-11

PubMed Abstract | CrossRef Full Text | Google Scholar

Gandhi, M., and Chikindas, M. L. (2007). Listeria: a foodborne pathogen that knows how to survive. Int. J. Food Microbiol. 113, 1–15. doi: 10.1016/j.ijfoodmicro.2006.07.008

PubMed Abstract | CrossRef Full Text | Google Scholar

Garner, D., and Kathariou, S. (2016). Fresh produce-associated listeriosis outbreaks, sources of concern, teachable moments, and insights. J. Food Prot. 79, 337–344. doi: 10.4315/0362-028X.JFP-15-387

PubMed Abstract | CrossRef Full Text | Google Scholar

Gerba, C. P. (2015). Quaternary ammonium biocides: efficacy in application. Appl. Environ. Microbiol. 81, 464–469. doi: 10.1128/AEM.02633–2614

CrossRef Full Text | Google Scholar

Hegstad, K., Langsrud, S., Lunestad, B. T., Scheie, A. A., Sunde, M., and Yazdankhah, S. P. (2010). Does the wide use of quaternary ammonium compounds enhance the selection and spread of antimicrobial resistance and thus threaten our health? Microb. Drug Resist. 16, 91–104. doi: 10.1089/mdr.2009.0120

PubMed Abstract | CrossRef Full Text | Google Scholar

Heir, E., Lindstedt, B. A., Røtterud, O. J., Vardund, T., Kapperud, G., and Nesbakken, T. (2004). Molecular epidemiology and disinfectant susceptibility of Listeria monocytogenes from meat processing plants and human infections. Int. J. Food Microbiol. 96, 85–96. doi: 10.1016/j.ijfoodmicro.2004.03.014

PubMed Abstract | CrossRef Full Text | Google Scholar

Jiang, X., Yu, T., Liang, Y., Ji, S., Guo, X., Ma, J., et al. (2015). Efflux pump-mediated benzalkonium chloride resistance in Listeria monocytogenes isolated from retail food. Int. J. Food Microbiol. 217, 141–145. doi: 10.1016/j.ijfoodmicro.2015.10.022

PubMed Abstract | CrossRef Full Text | Google Scholar

Kastbjerg, V. G., and Gram, L. (2009). Model systems allowing quantification of sensitivity to disinfectants and comparison of disinfectant susceptibility of persistent and presumed nonpersistent Listeria monocytogenes. J. Appl. Microbiol. 106, 1667–1681. doi: 10.1111/j.1365-2672.2008.04134.x

PubMed Abstract | CrossRef Full Text | Google Scholar

Kastbjerg, V. G., and Gram, L. (2012). Industrial disinfectants do not select for resistance in Listeria monocytogenes following long term exposure. Int. J. Food Microbiol. 160, 11–15. doi: 10.1016/j.ijfoodmicro.2012.09.009

PubMed Abstract | CrossRef Full Text | Google Scholar

Katharios-Lanwermeyer, S., Rakic-Martinez, M., Elhanafi, D., Ratani, S., Tiedje, J. M., and Kathariou, S. (2012). Coselection of cadmium and benzalkonium chloride resistance in conjugative transfers from nonpathogenic Listeria spp. to other Listeriae. Appl. Environ. Microbiol. 78, 7549–7556. doi: 10.1128/AEM.02245–2212

PubMed Abstract | CrossRef Full Text | Google Scholar

Kovacevic, J., Ziegler, J., Wałecka-Zacharska, E., Reimer, A., Kitts, D. D., and Gilmour, M. W. (2015). Tolerance of Listeria monocytogenes to quaternary ammonium sanitizers is mediated by a novel efflux pump encoded by emrE. Appl. Environ. Microbiol. 82, 939–953. doi: 10.1128/AEM.03741-15

PubMed Abstract | CrossRef Full Text | Google Scholar

Lemaitre, J. P., Echchannaoui, H., Michaut, G., Divies, C., and Rousset, A. (1998). Plasmid-mediated resistance to antimicrobial agents among listeriae. J. Food Protect. 61, 1459–1464.

PubMed Abstract | Google Scholar

Lianou, A., and Sofos, J. N. (2007). A review of the incidence and transmission of Listeria monocytogenes in ready-to-eat products in retail and food service environments. J. Food Prot. 70, 2172–2198.

PubMed Abstract | Google Scholar

Liu, X., Marrakchi, M., Jahne, M., Rogers, S., and Andreescu, S. (2016). Real-time investigation of antibiotics-induced oxidative stress and superoxide release in bacteria using an electrochemical biosensor. Free Radic. Biol. Med. 91, 25–33. doi: 10.1016/j.freeradbiomed.2015.12.001

PubMed Abstract | CrossRef Full Text | Google Scholar

Lundén, J. M., Autio, T. J., Markkula, A., Hellström, S., and Korkeala, H. (2003a). Adaptive and cross-adaptive responses of persistent and nonpersistent Listeria monocytogenes strains to disinfectants. Int. J. Food Microbiol. 82, 265–272. doi: 10.1016/S0168-1605(02)00312-4

CrossRef Full Text | Google Scholar

Lundén, J. M., Autio, T. J., Sjoberg, A. M., and Korkeala, H. J. (2003b). Persistent and nonpersistent Listeria monocytogenes contamination in meat and poultry processing plants. J. Food Prot. 66, 2062–2069.

PubMed Abstract | Google Scholar

Malley, T. J., Butts, J., and Wiedmann, M. (2015). Seek and destroy process: Listeria monocytogenes process controls in the ready-to-eat meat and poultry industry. J. Food Prot. 78, 436–445. doi: 10.4315/0362-028X.JFP-13-507

PubMed Abstract | CrossRef Full Text | Google Scholar

McLauchlin, J., Mitchell, R. T., Smerdon, W. J., and Jewell, K. (2004). Listeria monocytogenes and listeriosis: a review of hazard characterisation for use in microbiological risk assessment of foods. Int. J. Food Microbiol. 92, 15–33. doi: 10.1016/S0168-1605(03)00326-X

PubMed Abstract | CrossRef Full Text | Google Scholar

Mereghetti, L., Quentin, R., Mee, N., and Audurier, A. (2000). Low sensitivity of Listeria monocytogenes to quaternary ammonium compounds. Appl. Environ. Microbiol. 66, 5083–5086. doi: 10.1128/AEM.66.11.5083-5086.2000

CrossRef Full Text | Google Scholar

Morganti, M., Scaltriti, E., Cozzolino, P., Bolzoni, L., Casadei, G., Pierantoni, M., et al. (2015). Processing-dependent and clonal contamination patterns of Listeria monocytogenes in the cured ham food chain revealed by genetic analysis. Appl. Environ. Microbiol. 82, 822–831. doi: 10.1128/AEM.03103-15

PubMed Abstract | CrossRef Full Text | Google Scholar

Morrissey, I., Oggioni, M. R., Knight, D., Curiao, T., Coque, T., Kalkanci, A., et al. (2014). Evaluation of epidemiological cut-off values indicates that biocide resistant subpopulations are uncommon in natural isolates of clinically-relevant microorganisms. PLoS ONE 9:e86669. doi: 10.1371/journal.pone.0086669

PubMed Abstract | CrossRef Full Text | Google Scholar

Mullapudi, S., Siletzky, R. M., and Kathariou, S. (2008). Heavy-metal and benzalkonium chloride resistance of Listeria monocytogenes isolates from the environment of turkey-processing plants. Appl. Environ. Microbiol. 74, 1464–1468. doi: 10.1128/AEM.02426-07

PubMed Abstract | CrossRef Full Text | Google Scholar

Müller, A., Rychli, K., Muhterem-Uyar, M., Zaiser, A., Stessl, B., Guinane, C. M., et al. (2013). Tn6188 - a novel transposon in Listeria monocytogenes responsible for tolerance to benzalkonium chloride. PLoS ONE 8:e76835. doi: 10.1371/journal.pone.0076835

PubMed Abstract | CrossRef Full Text | Google Scholar

Nakamura, H., Takakura, K., Sone, Y., Itano, Y., and Nishikawa, Y. (2013). Biofilm formation and resistance to benzalkonium chloride in Listeria monocytogenes isolated from a fish processing plant. J. Food Prot. 76, 1179–1186. doi: 10.4315/0362-028X.JFP-12-225

PubMed Abstract | CrossRef Full Text | Google Scholar

Nakari, U. M., Rantala, L., Pihlajasaari, A., Toikkanen, S., Johansson, T., Hellsten, C., et al. (2014). Investigation of increased listeriosis revealed two fishery production plants with persistent Listeria contamination in Finland in 2010. Epidemiol. Infect. 142, 2261–2269. doi: 10.1017/S095026881300349X

PubMed Abstract | CrossRef Full Text | Google Scholar

Norwood, D., and Gilmour, A. (2000). The growth and resistance to sodium hypochlorite of Listeria monocytogenes in a steady-state multispecies biofilm. J. Appl. Microbiol. 88, 512–520. doi: 10.1046/j.1365-2672.2000.00990.x

PubMed Abstract | CrossRef Full Text | Google Scholar

Orsi, R. H., Borowsky, M. L., Lauer, P., Young, S. K., Nusbaum, C., Galagan, J. E., et al. (2008). Short-term genome evolution of Listeria monocytogenes in a non-controlled environment. BMC Genomics 9:539. doi: 10.1186/1471-2164-9-539

PubMed Abstract | CrossRef Full Text | Google Scholar

Ortiz, S. (2015). Diversidad Genética y Persistencia Ambiental de Listeria monocytogenes En Dos Plantas de Procesado de Carne de Cerdo Ibérico: Influencia de la Resistencia a Desinfectantes de Amonio Cuaternario. Ph.D. thesis, Universidad Complutense de Madrid, Madrid.

Ortiz, S., López, V., and Martínez-Suárez, J. V. (2014a). Control of Listeria monocytogenes contamination in an Iberian pork processing plant and selection of benzalkonium chloride-resistant strains. Food Microbiol. 39, 81–88. doi: 10.1016/j.fm.2013.11.007

PubMed Abstract | CrossRef Full Text | Google Scholar

Ortiz, S., López, V., and Martínez-Suárez, J. V. (2014b). The influence of subminimal inhibitory concentrations of benzalkonium chloride on biofilm formation by Listeria monocytogenes. Int. J. Food Microbiol. 189, 106–112. doi: 10.1016/j.ijfoodmicro.2014.08.007

PubMed Abstract | CrossRef Full Text | Google Scholar

Ortiz, S., López, V., Villatoro, D., López, P., Dávila, J. C., and Martínez-Suárez, J. V. (2010). A 3-year surveillance of the genetic diversity and persistence of Listeria monocytogenes in an Iberian pig slaughterhouse and processing plant. Foodborne Pathog. Dis. 7, 1177–1184. doi: 10.1089/fpd.2010.0535

PubMed Abstract | CrossRef Full Text | Google Scholar

Ortiz, S., López-Alonso, V., Rodríguez, P., and Martínez-Suárez, J. V. (2016). The connection between persistent, disinfectant-resistant Listeria monocytogenes strains from two geographically separate Iberian pork processing plants: evidence from comparative genome analysis. Appl. Environ. Microbiol. 82, 308–317. doi: 10.1128/AEM.02824-15

PubMed Abstract | CrossRef Full Text | Google Scholar

Pan, Y., Breidt, F. Jr., and Kathariou, S. (2006). Resistance of Listeria monocytogenes biofilms to sanitizing agents in a simulated food processing environment. Appl. Environ. Microbiol. 72, 7711–7717. doi: 10.1128/AEM.01065-06

PubMed Abstract | CrossRef Full Text | Google Scholar

Piddock, L. J. (2006). Clinically relevant chromosomally encoded multidrug resistance efflux pumps in bacteria. Clin. Microbiol. Rev. 19, 382–402. doi: 10.1128/CMR.19.2.382-402.2006

PubMed Abstract | CrossRef Full Text | Google Scholar

Rakic-Martinez, M., Drevets, D. A., Dutta, V., Katic, V., and Kathariou, S. (2011). Listeria monocytogenes strains selected on ciprofloxacin or the disinfectant benzalkonium chloride exhibit reduced susceptibility to ciprofloxacin, gentamicin, benzalkonium chloride, and other toxic compounds. Appl. Environ. Microbiol. 77, 8714–8721. doi: 10.1128/AEM.05941-11

PubMed Abstract | CrossRef Full Text | Google Scholar

Ratani, S. S., Siletzky, R. M., Dutta, V., Yildirim, S., Osborne, J. A., Lin, W., et al. (2012). Heavy metal and disinfectant resistance of Listeria monocytogenes from foods and food processing plants. Appl. Environ. Microbiol. 78, 6938–6945. doi: 10.1128/AEM.01553-12

PubMed Abstract | CrossRef Full Text | Google Scholar

Renier, S., Hébraud, M., and Desvaux, M. (2011). Molecular biology of surface colonization by Listeria monocytogenes: an additional facet of an opportunistic Gram-positive foodborne pathogen. Environ. Microbiol. 13, 835–850. doi: 10.1111/j.1462-2920.2010.02378.x

PubMed Abstract | CrossRef Full Text | Google Scholar

Romanova, N., Favrin, S., and Griffiths, M. W. (2002). Sensitivity of Listeria monocytogenes to sanitizers used in the meat processing industry. Appl. Environ. Microbiol. 68, 6405–6409. doi: 10.1128/AEM.68.12.6405-6409.2002

PubMed Abstract | CrossRef Full Text | Google Scholar

Romanova, N. A., Wolffs, P. F., Brovko, L. Y., and Griffiths, M. W. (2006). Role of efflux pumps in adaptation and resistance of Listeria monocytogenes to benzalkonium chloride. Appl. Environ. Microbiol. 72, 3498–3503. doi: 10.1128/AEM.72.5.3498-3503.2006

PubMed Abstract | CrossRef Full Text | Google Scholar

SCENIHR (2009). Scientific Committee on Emerging and Newly Identified Health Risks. Assessment of the Antibiotic Resistance Effects of Biocides. Brussels: European Commission. Health & Consumer Protection DG.

Schmitz-Esser, S., Müller, A., Stessl, B., and Wagner, M. (2015). Genomes of sequence type 121 Listeria monocytogenes strains harbor highly conserved plasmids and prophages. Front. Microbiol. 6:380. doi: 10.3389/fmicb.2015.00380

PubMed Abstract | CrossRef Full Text | Google Scholar

Shapiro, R. S. (2015). Antimicrobial-induced DNA damage and genomic instability in microbial pathogens. PLoS Pathog. 11:e1004678. doi: 10.1371/journal.ppat.1004678

PubMed Abstract | CrossRef Full Text | Google Scholar

Silk, B. J., Date, K. A., Jackson, K. A., Pouillot, R., Holt, K. G., Graves, L. M., et al. (2012). Invasive listeriosis in the foodborne diseases active surveillance network (FoodNet), 2004-2009: further targeted prevention needed for higher-risk groups. Clin. Infect. Dis. 54(Suppl. 5), S396–S404. doi: 10.1093/cid/cis268

PubMed Abstract | CrossRef Full Text | Google Scholar

Soumet, C., Ragimbeau, C., and Maris, P. (2005). Screening of benzalkonium chloride resistance in Listeria monocytogenes strains isolated during cold smoked fish production. Lett. Appl. Microbiol. 41, 291–296. doi: 10.1111/j.1472-765X.2005.01763.x

PubMed Abstract | CrossRef Full Text | Google Scholar

Stopforth, J. D., Samelis, J., Sofos, J. N., Kendall, P. A., and Smith, G. C. (2002). Biofilm formation by acid-adapted and nonadapted Listeria monocytogenes in fresh beef decontamination washings and its subsequent inactivation with sanitizers. J. Food Prot. 65, 1717–1727.

PubMed Abstract | Google Scholar

Tezel, U., and Pavlostathis, S. G. (2015). Quaternary ammonium disinfectants: microbial adaptation, degradation and ecology. Curr. Opin. Biotechnol. 33, 296–304. doi: 10.1016/j.copbio.2015.03.018

PubMed Abstract | CrossRef Full Text | Google Scholar

Thévenot, D., Dernburg, A., and Vernozy-Rozand, C. (2006). An updated review of Listeria monocytogenes in the pork meat industry and its products. J. Appl. Microbiol. 101, 7–17. doi: 10.1111/j.1365-2672.2006.02962.x

PubMed Abstract | CrossRef Full Text | Google Scholar

To, M. S., Favrin, S., Romanova, N., and Griffiths, M. W. (2002). Postadaptational resistance to benzalkonium chloride and subsequent physicochemical modifications of Listeria monocytogenes. Appl. Environ. Microbiol. 68, 5258–5264. doi: 10.1128/AEM.68.11.5258-5264.2002

PubMed Abstract | CrossRef Full Text | Google Scholar

Tompkin, R. B. (2002). Control of Listeria monocytogenes in the food-processing environment. J. Food Prot. 65, 709–725.

Google Scholar

van der Veen, S., and Abee, T. (2010). Importance of SigB for Listeria monocytogenes static and continuous-flow biofilm formation and disinfectant resistance. Appl. Environ. Microbiol. 76, 7854–7860. doi: 10.1128/AEM.01519-10

PubMed Abstract | CrossRef Full Text | Google Scholar

Xu, D., Li, Y., Zahid, M. S., Yamasaki, S., Shi, L., Li, J. R., et al. (2014). Benzalkonium chloride and heavy-metal tolerance in Listeria monocytogenes from retail foods. Int. J. Food Microbiol. 190, 24–30. doi: 10.1016/j.ijfoodmicro.2014.08.017

PubMed Abstract | CrossRef Full Text | Google Scholar

Zhang, H., Zhou, Y., Bao, H., Zhang, L., Wang, R., and Zhou, X. (2015). Plasmid-borne cadmium resistant determinants are associated with the susceptibility of Listeria monocytogenes to bacteriophage. Microbiol. Res. 172, 1–6. doi: 10.1016/j.micres.2015.01.008

PubMed Abstract | CrossRef Full Text | Google Scholar

Keywords: Listeria monocytogenes, food processing, bacterial persistence, quaternary ammonium disinfectants, resistance

Citation: Martínez-Suárez JV, Ortiz S and López-Alonso V (2016) Potential Impact of the Resistance to Quaternary Ammonium Disinfectants on the Persistence of Listeria monocytogenes in Food Processing Environments. Front. Microbiol. 7:638. doi: 10.3389/fmicb.2016.00638

Received: 09 March 2016; Accepted: 18 April 2016;
Published: 02 May 2016.

Edited by:

Juan Aguirre, Universidad de Chile, Chile

Reviewed by:

Alexandra Lianou, Agricultural University of Athens, Greece
Efstathios D. Giaouris, University of the Aegean, Greece

Copyright © 2016 Martínez-Suárez, Ortiz and López-Alonso. This is an open-access article distributed under the terms of the Creative Commons Attribution License (CC BY). The use, distribution or reproduction in other forums is permitted, provided the original author(s) or licensor are credited and that the original publication in this journal is cited, in accordance with accepted academic practice. No use, distribution or reproduction is permitted which does not comply with these terms.

*Correspondence: Joaquín V. Martínez-Suárez, joaquin@inia.es

Disclaimer: All claims expressed in this article are solely those of the authors and do not necessarily represent those of their affiliated organizations, or those of the publisher, the editors and the reviewers. Any product that may be evaluated in this article or claim that may be made by its manufacturer is not guaranteed or endorsed by the publisher.